Another CSC failure?

ChrisSlicks

The best stuff you can find right now at Autozone is Vavoline Synthetic brake fluid. It is actually pretty decent and cheap, has as dry boil point of 480F and a wet of 311F. I use it in all my non-track vehicles, I'm sure it is better than what is in there now.

I would also put the clutch spring back in, either stock or the lightweight one. You can have my lightweight one if you want, just pay shipping & handling.

__________________
Hotchkis ARB | Stillen CAI | Art Pipes | Berk CBE | Stillen AP Racing Brakes | AE Performance Oil Cooler | BC Racing ER Coilovers | Doran Control Arms

370Z Purist

I have since replaced the stock spring, which is kind of odd because the clutch pedal can't even fully actuate back to its unsprung position. I would actually like the lightweight spring, if your handling doesn't include a biochemical fuel charge for your food!

But it does look like the piston could and likely would be causing this problem. Its most odd because the fluid reservoir shows no change in level (right below max). I would think if the CSC failed, that the fluid would drain/leak, but I'm showing no change, which also leads to me to think the CSC failed because the fluid isn't the issue.

__________________
-Phil

"Since one of my brake light bulbs just went out, the forum told me that my piston rings are about to blow."

kenchan

yep, i think it's your piston so fluid change will net you probably nothing... thus i think you should have the dealer replace the unit and bring her home.

ChrisSlicks

The pedal sticks down if there isn't sufficient hydraulic pressure to return it. Definitely sounds like air in the system. Now the reason the air is there is because of 1 of 2 things, either the fluid boiled due to fluid contamination that lowered the boiling point, or air entered the system somewhere. The later seems unlikely at this point as if that were the case then fluid could also leak out the same place.

Just bleed it, takes all of 5-10 minutes. Takes more time getting the car jacked up to get access to the bleed screw.

__________________
Hotchkis ARB | Stillen CAI | Art Pipes | Berk CBE | Stillen AP Racing Brakes | AE Performance Oil Cooler | BC Racing ER Coilovers | Doran Control Arms

370Z Purist

Bleeding isn't a bad idea. If anything, worst case scenario would be guaranteed, so I might as well take half an hour and bleed with fresh, 10 dollar fluid than dismiss it immediately as CSC failure.

__________________
-Phil

"Since one of my brake light bulbs just went out, the forum told me that my piston rings are about to blow."

Mt Tam I am

I do not know if this post should be here or not but here goes.

I just changed my brake fluid to DOT 5.1 and had some left over and changed my clutch fluid. It was black and looked like it had well over 13,000 miles on it.

__________________
Nissan Motorsports 34R Oil Cooler. Stillen CBE. Hotchkis Sport Sway Bars. KW Variant 3 Coilover System. Stillen Gen3 CAI. Michelin Pilot Super Sport. Stillen Brake Ducts. Carbotech™ XP10/XP8 Pads. Z1 Front Rotors. Z1 Stainless Brake Lines. Two degrees of camber