HKS Hi-Power Installed and Reviewed

Alstann · 04-29-2012, 11:12 PM

Hey guys,

A few days ago, I got around to installing my HKS Hi-Power exhaust system I bought used from a forum member. I wanted to share my opinions and whatnot with you guys, in case you looked at getting the HKS system for your own car.

The Install:

I forgot to take pictures of removing my stock exhaust, but it's not too difficult. I first sprayed everything with Penetrating Blaster, then used a 1/2 drive breaker bar to loosen all the bolts from the cat back. In order, I removed the rear muffler section, then the mid pipe, then the y-pipe. One trick I found was that all the rubber exhaust hangers are bolted to the frame, not welded. I unbolted all of them to facilitate removing the stock exhaust easier, and then once off the car, I used WD-40 and my hands to wedge the hangers off. Much much much easier that way.

Here's a pic of the stock and HKS exhausts side by side. If you look closely, you can see the rubber hangers and their mountings next to the stock exhaust. I would also like to say that our stock Y-pipe is pathetic - the y collector was about the same size as ONE SIDE of the HKS H-pipe. Major restriction.

Of course, installation of the HKS was as easy as reversing the removal of the stock exhaust. I first rebolted the rubber exhaust hangers back to the car, and then installed the H-pipe, then the midpipes, then the rear exhaust sections.

Since I was working alone, I had trouble holding the H-pipe up without stressing the headers and the cats. I used a bungee cord wrapped around the driveshaft to hold the H-pipe up while I maneuvered the midpipes in place.

After that, the rear sections go on one by one, and then I just simply bolted up everything tight as possible, with a ratchet and the breaker bar. I used lock washers as well as flat washers to make sure nothing got loose or rattled.

The Review:

First off - let me say, this exhaust sounds absolutely amazing, albeit a tad quiet for my tastes (I am on stock cats). This is definitely how the car should have sounded from the factory. The tone is deep and clear, especially accelerating from 2k to 4k. It really makes driving the car so much more fun.

As for the noise level, it is not the loudest of exhausts, unless you cold start it. When cruising around town, you can hear it when you accelerate at 1/2 throttle or more, but it quiets down to nearly stock exhaust levels when you just maintain your speed. I consider it perfect if you wish to have a quiet car while driving normally, but loud and sonorous when you step on it. On the highway, cruising at 75, you can't hear a thing - something I consider amazing for a performance exhaust system.

On the other side, it roars beautifully all the way to redline. And dont even get me started with downshifting - you'll need new underwear if you downshift through a tunnel or under an overpass.

Also, there is ABSOLUTELY NO DRONE. Zip, zero, zilch. From every speed I tested, ranging from 0-85 mph, there was no range where you heard any resonance in the cabin or annoying drone. HKS did an incredible job with their resonator and Hemholtz tuning. Their welding is also top notch, with really thick exhaust flanges and welds that inspire confidence in a long lasting product.

Fitment wise, I would give it a 9 out of 10. Reason being, the right side physically contacts this black metal shielding that shields some rubber hoses, and when I first went on a drive, it made some vibrating noises over bumpy ground and it drove me insane. My stopgap fix for this was to wedge a rubber door stop (I'll take a picture later to show the issue) between the muffler can and the black shielding. My permanent fix will be to dremel back the black shielding a bit to give some clearance. Also, the exhaust tips are NEARLY perfectly aligned with each other - the right side sits slightly lower than the left, but it would take eagle eyes and some careful observation to spot it. I consider it pretty darn good fitment. When I get the EVO-R diffuser, the issue will not be noticeable at all.

Performance-wise, I definitely feel the boost in power and torque. The car seems to respond to lower RPM's much better, with no hesitation or anything, and up top, the car seems to be sailing through the gears. The noise also begs me to push the car hard. I did forget to reset my ECU with a battery disconnect - I'll probably be doing that tomorrow morning and I'll report back on that.

I would also like to mention this is my only performance mod - I am on stock tune, intakes, cats, headers, etc.

As for the appearance and looks of the exhaust, I personally think it is one of the best looking exhausts. I prefer the angled can design more than the stock-style muffler design. Fast Intentions was the other exhaust I debated for quite a while, but I couldn't pass up a great local deal. Sorry Tony!

The titanium exhaust tips are GORGEOUS. They are indeed length adjustable, and after I polished the rear sections and the tips with metal polish, I couldn't help but stare at my car's rear end like it was a pretty lady. (NOTE: Do NOT polish the Ti tips by machine - this will REMOVE the coloration of the tips. I hand polished them slowly with a microfiber towel, and it came out pristine. I took a polishing wheel with my dremel to a part of the blue burn, and it came off within half a second. Then again, I used a dremel spinning pretty damn fast, but better to be safe and use your hand!)

I won't be tuning the car until I get full bolt ons, but I may be getting a dyno done again soon to see the gains. I have a baseline dyno already of my stock setup.

**EDIT** Having recently removed the black shield on the passenger side, as well as unbolting the midsection and realigning it, the HKS exhaust sits PERFECTLY on my car. Symmetrical as could be.

FairladyZ · 04-29-2012, 11:18 PM

Quote:

Originally Posted by Alstann

Hey guys,

A few days ago, I got around to installing my HKS Hi-Power exhaust system I bought used from a forum member. I wanted to share my opinions and whatnot with you guys, in case you looked at getting the HKS system for your own car.

The Install:

I forgot to take pictures of removing my stock exhaust, but it's not too difficult. I first sprayed everything with Penetrating Blaster, then used a 1/2 drive breaker bar to loosen all the bolts from the cat back. In order, I removed the rear muffler section, then the mid pipe, then the y-pipe. One trick I found was that all the rubber exhaust hangers are bolted to the frame, not welded. I unbolted all of them to facilitate removing the stock exhaust easier, and then once off the car, I used WD-40 and my hands to wedge the hangers off. Much much much easier that way.

Here's a pic of the stock and HKS exhausts side by side. If you look closely, you can see the rubber hangers and their mountings next to the stock exhaust. I would also like to say that our stock Y-pipe is pathetic - the y collector was about the same size as ONE SIDE of the HKS H-pipe. Major restriction.

Of course, installation of the HKS was as easy as reversing the removal of the stock exhaust. I first rebolted the rubber exhaust hangers back to the car, and then installed the H-pipe, then the midpipes, then the rear exhaust sections.

Since I was working alone, I had trouble holding the H-pipe up without stressing the headers and the cats. I used a bungee cord wrapped around the driveshaft to hold the H-pipe up while I maneuvered the midpipes in place.

After that, the rear sections go on one by one, and then I just simply bolted up everything tight as possible, with a ratchet and the breaker bar. I used lock washers as well as flat washers to make sure nothing got loose or rattled.

The Review:

First off - let me say, this exhaust sounds absolutely amazing, albeit a tad quiet for my tastes (I am on stock cats). This is definitely how the car should have sounded from the factory. The tone is deep and clear, especially accelerating from 2k to 4k. It really makes driving the car so much more fun.

As for the noise level, it is not the loudest of exhausts, unless you cold start it. When cruising around town, you can hear it when you accelerate at 1/2 throttle or more, but it quiets down to nearly stock exhaust levels when you just maintain your speed. I consider it perfect if you wish to have a quiet car while driving normally, but loud and sonorous when you step on it. On the highway, cruising at 75, you can't hear a thing - something I consider amazing for a performance exhaust system.

On the other side, it roars beautifully all the way to redline. And dont even get me started with downshifting - you'll need new underwear if you downshift through a tunnel or under an overpass.

Also, there is ABSOLUTELY NO DRONE. Zip, zero, zilch. From every speed I tested, ranging from 0-85 mph, there was no range where you heard any resonance in the cabin or annoying drone. HKS did an incredible job with their resonator and Hemholtz tuning. Their welding is also top notch, with really thick exhaust flanges and welds that inspire confidence in a long lasting product.

Fitment wise, I would give it a 9 out of 10. Reason being, the right side physically contacts this black metal shielding that shields some rubber hoses, and when I first went on a drive, it made some vibrating noises over bumpy ground and it drove me insane. My stopgap fix for this was to wedge a rubber door stop (I'll take a picture later to show the issue) between the muffler can and the black shielding. My permanent fix will be to dremel back the black shielding a bit to give some clearance. Also, the exhaust tips are NEARLY perfectly aligned with each other - the right side sits slightly lower than the left, but it would take eagle eyes and some careful observation to spot it. I consider it pretty darn good fitment. When I get the EVO-R diffuser, the issue will not be noticeable at all.

Performance-wise, I definitely feel the boost in power and torque. The car seems to respond to lower RPM's much better, with no hesitation or anything, and up top, the car seems to be sailing through the gears. The noise also begs me to push the car hard. I did forget to reset my ECU with a battery disconnect - I'll probably be doing that tomorrow morning and I'll report back on that.

I would also like to mention this is my only performance mod - I am on stock tune, intakes, cats, headers, etc.

As for the appearance and looks of the exhaust, I personally think it is one of the best looking exhausts. I prefer the angled can design more than the stock-style muffler design. Fast Intentions was the other exhaust I debated for quite a while, but I couldn't pass up a great local deal. Sorry Tony!

The titanium exhaust tips are GORGEOUS. They are indeed length adjustable, and after I polished the rear sections and the tips with metal polish, I couldn't help but stare at my car's rear end like it was a pretty lady.

I won't be tuning the car until I get full bolt ons, but I may be getting a dyno done again soon to see the gains. I have a baseline dyno already of my stock setup.

That piece you are talking about where the exhaust is rubbing or hitting was suppose to be removed alltogether.

007MI6 · 04-29-2012, 11:22 PM

Cool write up man. Thanks for taking the time to write it.

MacLean · 04-29-2012, 11:40 PM

Nice write up & pics. I'm glad you are happy & impressed with your purchase & the way she sounds now. Have fun driving around town.

Alstann · 04-30-2012, 08:50 AM

Quote:

Originally Posted by FairladyZ

That piece you are talking about where the exhaust is rubbing or hitting was suppose to be removed alltogether.

In that case, I am a monumental idiot.

Thanks for the tip - I'll just be removing it then instead of screwing with it. In that case, I have no complaints with the exhaust fitment.

Quote:

Originally Posted by 007MI6

Cool write up man. Thanks for taking the time to write it.

No problem! The HKS is really an awesome exhaust. Pricey when brand new, but if you get a deal or anything, I highly recommend it.

Quote:

Originally Posted by cgmg21

Nice write up & pics. I'm glad you are happy & impressed with your purchase & the way she sounds now. Have fun driving around town.

It feels like driving a new car again - the excitement is back when you can finally hear how this car is supposed to sound! I can't wait to finally get around to installing my High Flow Cats, I believe this will make the perfect volume and sound I am looking for.

KB2 · 04-30-2012, 02:32 PM

by far one of the best looking exhausts for the z

wheee! · 04-30-2012, 02:38 PM

Quote:

Originally Posted by FairladyZ

That piece you are talking about where the exhaust is rubbing or hitting was suppose to be removed alltogether.

^ this....

... and I think there are a set of lightly used Berk HFC's for sale on the forum right now. Jump on them, the combo is amazing!

Alstann · 04-30-2012, 03:25 PM

Quote:

Originally Posted by wheee!

^ this....

... and I think there are a set of lightly used Berk HFC's for sale on the forum right now. Jump on them, the combo is amazing!

I actually have a set of the Berk HFC's sitting in my attic, ready to install! I was forced to stop the installation on them last month due to time constraints, and me breaking 2 swivel extensions (3/8 drive set, totally useless on demon bolts.) I got around and got a whole set of 1/2 drive stuff, and I'm ready to tackle the challenge again. My school semester ends in a few days, so I might have them on in a jiffy.

Do you happen to have any videos of your setup, wheee? I would love to indulge in that combo.

wheee! · 04-30-2012, 03:58 PM

I'll see what I can find... it is a very sweet setup!

Check out Linparks journal LinPark's 370Z Journal

He has the same setup as me (

copycat!) and he is in Florida, might be local to you....

anthonyy · 04-30-2012, 04:52 PM

Quote:

Originally Posted by KB2

by far one of the best looking exhausts for the z

definitely one of the best LOOKING

MaDMaXX · 04-30-2012, 04:55 PM

Vids!!!

phelan · 04-30-2012, 04:58 PM

HKS exhausts are typically like that - quiet on normal driving, but they respond in rapturous voice when you step on the throttle. not only the Z exhausts, but their subaru legamax systems are the same thing. the nice thing about it is that you're not howling 24/7, so less chance of cops going "wtf" as you drive by

good pickup, thanks for the review!

Alstann · 05-01-2012, 06:23 PM

Quote:

Originally Posted by phelan

HKS exhausts are typically like that - quiet on normal driving, but they respond in rapturous voice when you step on the throttle. not only the Z exhausts, but their subaru legamax systems are the same thing. the nice thing about it is that you're not howling 24/7, so less chance of cops going "wtf" as you drive by

good pickup, thanks for the review!

It's definitely a good thing - my neighbors and cops have no complaints about the noise level. Sounds nearly stock under load. Of course, I do prefer a louder exhaust, at least louder than what just the HKS offers. I hope HFC's will resolve that issue.

Quote:

Originally Posted by wheee!

I'll see what I can find... it is a very sweet setup!

Check out Linparks journal LinPark's 370Z Journal

He has the same setup as me (

copycat!) and he is in Florida, might be local to you....

Sweet, thanks weeee. Like I was saying, I'm sure HFC's will make the exhaust loud enough to the point I can really hear it windows down, and that is exactly what I am looking for.

Quote:

Originally Posted by MaDMaXX

Vids!!!

I am very interested in doing some videos for the exhaust! It's been raining pretty much every day here in South FL, so it might be a bit. I want to get videos of cold start, warm start, takeoff, downshifts, and drive-by cruising and light accel. Should be a nice all rounder for anyone interested in getting this exhaust.

LakeShow · 05-01-2012, 06:48 PM

Very nice! Video clip time!

zero · 05-01-2012, 07:03 PM

Nice review. Get HFC with it and you'll be smiling every time you hammering down the throttle.

04-29-2012, 11:12 PM	#1 (permalink)
Alstann Track Member Join Date: Oct 2011 Location: South Florida Posts: 882 Drives: 12 PW 370z 6MT Sport Rep Power: 15	HKS Hi-Power Installed and Reviewed Hey guys, A few days ago, I got around to installing my HKS Hi-Power exhaust system I bought used from a forum member. I wanted to share my opinions and whatnot with you guys, in case you looked at getting the HKS system for your own car. The Install: I forgot to take pictures of removing my stock exhaust, but it's not too difficult. I first sprayed everything with Penetrating Blaster, then used a 1/2 drive breaker bar to loosen all the bolts from the cat back. In order, I removed the rear muffler section, then the mid pipe, then the y-pipe. One trick I found was that all the rubber exhaust hangers are bolted to the frame, not welded. I unbolted all of them to facilitate removing the stock exhaust easier, and then once off the car, I used WD-40 and my hands to wedge the hangers off. Much much much easier that way. Here's a pic of the stock and HKS exhausts side by side. If you look closely, you can see the rubber hangers and their mountings next to the stock exhaust. I would also like to say that our stock Y-pipe is pathetic - the y collector was about the same size as ONE SIDE of the HKS H-pipe. Major restriction. Of course, installation of the HKS was as easy as reversing the removal of the stock exhaust. I first rebolted the rubber exhaust hangers back to the car, and then installed the H-pipe, then the midpipes, then the rear exhaust sections. Since I was working alone, I had trouble holding the H-pipe up without stressing the headers and the cats. I used a bungee cord wrapped around the driveshaft to hold the H-pipe up while I maneuvered the midpipes in place. After that, the rear sections go on one by one, and then I just simply bolted up everything tight as possible, with a ratchet and the breaker bar. I used lock washers as well as flat washers to make sure nothing got loose or rattled. The Review: First off - let me say, this exhaust sounds absolutely amazing, albeit a tad quiet for my tastes (I am on stock cats). This is definitely how the car should have sounded from the factory. The tone is deep and clear, especially accelerating from 2k to 4k. It really makes driving the car so much more fun. As for the noise level, it is not the loudest of exhausts, unless you cold start it. When cruising around town, you can hear it when you accelerate at 1/2 throttle or more, but it quiets down to nearly stock exhaust levels when you just maintain your speed. I consider it perfect if you wish to have a quiet car while driving normally, but loud and sonorous when you step on it. On the highway, cruising at 75, you can't hear a thing - something I consider amazing for a performance exhaust system. On the other side, it roars beautifully all the way to redline. And dont even get me started with downshifting - you'll need new underwear if you downshift through a tunnel or under an overpass. Also, there is ABSOLUTELY NO DRONE. Zip, zero, zilch. From every speed I tested, ranging from 0-85 mph, there was no range where you heard any resonance in the cabin or annoying drone. HKS did an incredible job with their resonator and Hemholtz tuning. Their welding is also top notch, with really thick exhaust flanges and welds that inspire confidence in a long lasting product. Fitment wise, I would give it a 9 out of 10. Reason being, the right side physically contacts this black metal shielding that shields some rubber hoses, and when I first went on a drive, it made some vibrating noises over bumpy ground and it drove me insane. My stopgap fix for this was to wedge a rubber door stop (I'll take a picture later to show the issue) between the muffler can and the black shielding. My permanent fix will be to dremel back the black shielding a bit to give some clearance. Also, the exhaust tips are NEARLY perfectly aligned with each other - the right side sits slightly lower than the left, but it would take eagle eyes and some careful observation to spot it. I consider it pretty darn good fitment. When I get the EVO-R diffuser, the issue will not be noticeable at all. Performance-wise, I definitely feel the boost in power and torque. The car seems to respond to lower RPM's much better, with no hesitation or anything, and up top, the car seems to be sailing through the gears. The noise also begs me to push the car hard. I did forget to reset my ECU with a battery disconnect - I'll probably be doing that tomorrow morning and I'll report back on that. I would also like to mention this is my only performance mod - I am on stock tune, intakes, cats, headers, etc. As for the appearance and looks of the exhaust, I personally think it is one of the best looking exhausts. I prefer the angled can design more than the stock-style muffler design. Fast Intentions was the other exhaust I debated for quite a while, but I couldn't pass up a great local deal. Sorry Tony! The titanium exhaust tips are GORGEOUS. They are indeed length adjustable, and after I polished the rear sections and the tips with metal polish, I couldn't help but stare at my car's rear end like it was a pretty lady. (NOTE: Do NOT polish the Ti tips by machine - this will REMOVE the coloration of the tips. I hand polished them slowly with a microfiber towel, and it came out pristine. I took a polishing wheel with my dremel to a part of the blue burn, and it came off within half a second. Then again, I used a dremel spinning pretty damn fast, but better to be safe and use your hand!) I won't be tuning the car until I get full bolt ons, but I may be getting a dyno done again soon to see the gains. I have a baseline dyno already of my stock setup. EDIT Having recently removed the black shield on the passenger side, as well as unbolting the midsection and realigning it, the HKS exhaust sits PERFECTLY on my car. Symmetrical as could be. ohmikegod and forza370z like this. __________________ 2012 Pearl White 370Z GReddy Twin Turbo Last edited by Alstann; 10-01-2012 at 09:11 PM.

04-29-2012, 11:22 PM	#3 (permalink)
007MI6 Track Member Join Date: May 2011 Location: Corpus Christi, TX Age: 45 Posts: 703 Drives: Audrey Rep Power: 15	Cool write up man. Thanks for taking the time to write it. __________________ 2011 370Z Touring+Sport Coupe BLK Int\|\|M6\|\|Navigation\|\|Illuminated Door Sills\|\|GoMiniGo LPB

04-30-2012, 03:58 PM	#9 (permalink)
wheee! A True Z Fanatic Join Date: Sep 2009 Location: Mod Capital of Canada Age: 58 Posts: 7,354 Drives: cars. lots of cars. Rep Power: 40182	I'll see what I can find... it is a very sweet setup! Check out Linparks journal LinPark's 370Z Journal He has the same setup as me ( copycat!) and he is in Florida, might be local to you.... __________________ H&R / Stillen / Berk / HKS / Swift / Michelin / UpRev / SPC / Amuse Rep / Seibon / Fringe XVO / TWM / more... My Journal Last edited by wheee!; 04-30-2012 at 04:03 PM.

04-30-2012, 04:58 PM	#12 (permalink)
phelan A True Z Fanatic Join Date: Apr 2009 Location: CA Age: 38 Posts: 9,513 Drives: Scoobaroo Rep Power: 3406	HKS exhausts are typically like that - quiet on normal driving, but they respond in rapturous voice when you step on the throttle. not only the Z exhausts, but their subaru legamax systems are the same thing. the nice thing about it is that you're not howling 24/7, so less chance of cops going "wtf" as you drive by good pickup, thanks for the review! __________________ 凛 ('Rin') - 2009 Nissan 370Z With silence comes peace. With peace comes freedom. With freedom comes silence.

05-01-2012, 06:48 PM	#14 (permalink)
LakeShow A True Z Fanatic Join Date: Dec 2010 Location: L.I., NY Posts: 5,307 Drives: Everything Rep Power: 26	Very nice! Video clip time! __________________ \|2013 Audi S4\|Ibis White/Black\|S-Tronic P+\| \|2013 370z\|PearlWhite/Persimmon\|Touring/Sport/Nav\|F.I. CBE 18" CF\| \|Sold\|2011 370z\|Gun Metallic\|Touring/Sport/Nav\|

04-29-2012, 11:40 PM	#4 (permalink)
MacLean A True Z Fanatic Join Date: Apr 2012 Location: Houston Posts: 1,589 Drives: '12 GM Nismo # 0445 Rep Power: 16	Nice write up & pics. I'm glad you are happy & impressed with your purchase & the way she sounds now. Have fun driving around town.

04-30-2012, 02:32 PM	#6 (permalink)
KB2 Base Member Join Date: Apr 2010 Location: Illinois Posts: 243 Drives: 370z Rep Power: 15	by far one of the best looking exhausts for the z

04-30-2012, 04:55 PM	#11 (permalink)
MaDMaXX Enthusiast Member Join Date: Jan 2012 Location: Oregon from England Posts: 292 Drives: 350z Rep Power: 13	Vids!!!

05-01-2012, 07:03 PM	#15 (permalink)
zero A True Z Fanatic Join Date: Dec 2008 Location: Southern California Posts: 1,259 Drives: MK 7.5 Golf R Rep Power: 23	Nice review. Get HFC with it and you'll be smiling every time you hammering down the throttle. __________________

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
HKS HI-POWER exhaust installed and review	ilive2win	Intake/Exhaust	57	04-18-2012 11:28 PM
Just installed Agency Power CBE and ERZ HFC	dudesky	Intake/Exhaust	18	08-27-2011 05:28 PM
HKS HI-Power Exhaust Shipping Damage Sale!! - Brand New Never Installed - Great Price	Coz@Czp	Exhaust/Intake	6	08-16-2011 04:05 PM
GTM SC installs reviewed	Zsteve	Forced Induction	248	11-16-2010 02:17 AM
HPLogic Reviewed	RCZ	South East Region	4	05-06-2009 09:32 PM