Vit's FI TT 370Z Lives!

Jhill · 09-21-2016, 08:02 PM

Quote:

Originally Posted by VitViper

Took the car out for a good hit today, just running 7psi to stay under the limit of the fuel pump lol. It's a whole new car -- response is better, boost comes in much better (to the point I gotta dial it back a bit).

So nice to have true closed loop boost by gear!

The knock control is great, I honestly have the threshold too tight right now since I'm experimenting and making sure it all works well.

I'm also using the lateral G's coming from the ABS/VDC to trim the traction control -- so as you pull lateral G's the system hunkers down, works great!

One of the challenges of the VVEL motors using a VE based system -- making sure fueling is correct as it can vary DRASTICALLY based on the VVEL target (even based on TPS vs VVEL at points). It's a fantastic system -- I love it. I've found I can set VVEL targets that make just enough power to just cruise down the high way, but even if you floor it (100% TPS) the car won't accelerate or barely creeps, LOL.

But back to the fueling -- you can literally spend hours upon hours to get it all "right", but I don't want anyone to spend that much fiddling with it, so I've already done most of the work in dialing in the VVEL comp tables.

But this still won't be 100% perfect, and me being really picky, I want it perfect -- so what do we do? I programmed the ECU to learn, either while you're on the dyno or just driving the car, then it applies the learned VE trims and you have spot on fueling. You can disable learning once you're happy with it and only let it apply (IE for long term in case your lambda sensors fault, you don't want the learned tables skewing anything).

Yes it retains the learned data between engine key cycles, it's flash backed

.

Man this is way more than I need but way cool!!

So is this your own stand alone unit you made or modifying another stand alone? Really cool system, reading more and more about tuning and stand alones in general and it's pretty amazing what can be done now.

VitViper · 09-21-2016, 08:09 PM

Quote:

Originally Posted by Jhill

Man this is way more than I need but way cool!!

So is this your own stand alone unit you made or modifying another stand alone? Really cool system, reading more and more about tuning and stand alones in general and it's pretty amazing what can be done now.

It's a MoTeC M1 ECU. The ECU's are just blank hardware when we buy them. I write the firmware we use (the code that runs the ecu) to suit whatever application we're working on-- which is part of what allows me to integrate VVEL control, the factory Nissan CAN bus data, etc.

I already have firmware out for various Honda B series, K series, F series applications, 06-15 Honda Civic Si and R18 applications. As well as the Toyota 86 platform, now the 370Z stuff. Next on the plate is the Evo 8 & Evo 10, as well as a new 15+ Mustang.

PongSanity · 09-21-2016, 10:07 PM

Ballpark price on stand alone?

Sent from my iPhone using Tapatalk

Elmo370z · 09-21-2016, 11:28 PM

3000-10000. Syvecs s6 unit should also fall inbetween that price range.

VitViper · 09-21-2016, 11:41 PM

Quote:

Originally Posted by Elmo370z

3000-10000. Syvecs s6 unit should also fall inbetween that price range.

6k+, retail on an M150 is $3770. I'm familiar with Syvecs, however I don't see them having a full drop in replacement ECU for the 370Z with VVEL control, CAN BUS programming, cruise control, working fuel economy meters, etc. Any ECU targetted at a 350Z *will not* work on this car. An S6 unit also will not run everything on a 370Z -- it's only got a single lambda, single knock input, etc. It's a very basic ecu.

Borrowed a buddy's Go Pro, took the car out for a spin. You can see/hear the traction control logic at work.

https://www.youtube.com/watch?v=ykO6e4L7trY

I <3 how the car sounds with the F/I kit & exhaust.

Spooler · 09-22-2016, 01:35 PM

That is great work with one bad axx ECU.

VitViper · 09-23-2016, 04:31 PM

Cranked it up a bit yesterday, the boost by gear doing work!

I think with proper tuning 14psi or so isn't out of the picture on 92-93 octane fuel. This should be about ~600whp or so on pump gas.

Couldn't do it before due to the clipping point of the stock mafs.

Fun little gimmick that I programmed in the ECU -- power estimate based on accelerate rate (of non driven tire, so no wheel sleep problems here). Obviously instantaneous accel is kind of "jittery", so you can factor it to "smooth" it, I'm using too much in this example, and it got a smoothed graph that looks nice, but very very low ball values compared to instant, hah.

VitViper · 09-23-2016, 11:22 PM

And here you have it folks, worked out the fuel pump (fixed itself?) and replaced the cam sensor. Making some great power on good ol' 92 octane fuel.

VitViper · 09-24-2016, 01:21 AM

https://www.youtube.com/watch?v=a8q4_rUpLfs

VitViper · 10-07-2016, 07:42 PM

Cruising down the highway with no vacuum in the manifold at all, no problem.

Great still getting 22-26mpg depending on weather (was getting 22mpg in the rain with a head wind, not bad at all lol).

VitViper · 10-19-2016, 07:00 PM

Welcome to true flex fuel logic. No analog converters here -- we run the content sensor directly as the digital signal it is, to not only get flex content, but fuel temp from it as well. Going to need a fuel system upgrade from @phunk soon I'm sure, as my fuel system is pretty tapped out as it is, lol.

phunk · 10-19-2016, 07:15 PM

Quote:

Originally Posted by VitViper

Welcome to true flex fuel logic. No analog converters here -- we run the content sensor directly as the digital signal it is, to not only get flex content, but fuel temp from it as well. Going to need a fuel system upgrade from @phunk soon I'm sure, as my fuel system is pretty tapped out as it is, lol.

I like that.. sucks having to buy an E85 content gauge kit just to get an output to use with the ECUTEK.

VitViper · 10-19-2016, 07:59 PM

Quote:

Originally Posted by phunk

I like that.. sucks having to buy an E85 content gauge kit just to get an output to use with the ECUTEK.

In the past I would just use the analog converter boxes without the gauges. I HATE gauges, I feel like they clutter up the car and are absolutely useless (boost/afr/content, etc -- who can really watch them when you're hauling ***?)

The stock ecu has a lot of limitations... 10hz output for boost control? eeww, so bad, lol. And the amount of inputs for extra stuff is extremely limited too.

VitViper · 11-01-2016, 10:32 PM

Listen to that chop lol

https://www.facebook.com/vittuned/vi...9404851604514/

PongSanity · 11-10-2016, 12:58 PM

That's cam ghosting?

Sent from my iPhone using Tapatalk

09-23-2016, 04:31 PM	#67 (permalink)
VitViper Base Member Join Date: Jul 2015 Location: Oregon Posts: 125 Drives: 15 370Z Rep Power: 16	Cranked it up a bit yesterday, the boost by gear doing work! I think with proper tuning 14psi or so isn't out of the picture on 92-93 octane fuel. This should be about ~600whp or so on pump gas. Couldn't do it before due to the clipping point of the stock mafs. Fun little gimmick that I programmed in the ECU -- power estimate based on accelerate rate (of non driven tire, so no wheel sleep problems here). Obviously instantaneous accel is kind of "jittery", so you can factor it to "smooth" it, I'm using too much in this example, and it got a smoothed graph that looks nice, but very very low ball values compared to instant, hah. hjo1078 likes this.

09-23-2016, 11:22 PM	#68 (permalink)
VitViper Base Member Join Date: Jul 2015 Location: Oregon Posts: 125 Drives: 15 370Z Rep Power: 16	And here you have it folks, worked out the fuel pump (fixed itself?) and replaced the cam sensor. Making some great power on good ol' 92 octane fuel. hjo1078, Elmo370z, EliteXpress and 1 others like this.

09-24-2016, 01:21 AM	#69 (permalink)
VitViper Base Member Join Date: Jul 2015 Location: Oregon Posts: 125 Drives: 15 370Z Rep Power: 16	https://www.youtube.com/watch?v=a8q4_rUpLfs hjo1078 and Hotrodz like this.

10-07-2016, 07:42 PM	#70 (permalink)
VitViper Base Member Join Date: Jul 2015 Location: Oregon Posts: 125 Drives: 15 370Z Rep Power: 16	Cruising down the highway with no vacuum in the manifold at all, no problem. Great still getting 22-26mpg depending on weather (was getting 22mpg in the rain with a head wind, not bad at all lol). phunk likes this.

10-19-2016, 07:00 PM	#71 (permalink)
VitViper Base Member Join Date: Jul 2015 Location: Oregon Posts: 125 Drives: 15 370Z Rep Power: 16	Welcome to true flex fuel logic. No analog converters here -- we run the content sensor directly as the digital signal it is, to not only get flex content, but fuel temp from it as well. Going to need a fuel system upgrade from @phunk soon I'm sure, as my fuel system is pretty tapped out as it is, lol. phunk likes this.

09-21-2016, 10:07 PM	#63 (permalink)
PongSanity Enthusiast Member Join Date: Jul 2014 Location: Virgin Islands Posts: 261 Drives: '09 G37s KH3 6MT Rep Power: 11	Ballpark price on stand alone? Sent from my iPhone using Tapatalk

09-21-2016, 11:28 PM	#64 (permalink)
Elmo370z A True Z Fanatic Join Date: Apr 2013 Location: st. petersburg Posts: 5,709 Drives: 09 nissan 370z Sp M6 Rep Power: 295378	3000-10000. Syvecs s6 unit should also fall inbetween that price range.

09-22-2016, 01:35 PM	#66 (permalink)
Spooler A True Z Fanatic Join Date: Jun 2014 Location: Ga Posts: 13,834 Drives: 2013 Nismo 370z Rep Power: 2684392	That is great work with one bad axx ECU.

11-01-2016, 10:32 PM	#74 (permalink)
VitViper Base Member Join Date: Jul 2015 Location: Oregon Posts: 125 Drives: 15 370Z Rep Power: 16	Listen to that chop lol https://www.facebook.com/vittuned/vi...9404851604514/ VQZ34nismo likes this.

11-10-2016, 12:58 PM	#75 (permalink)
PongSanity Enthusiast Member Join Date: Jul 2014 Location: Virgin Islands Posts: 261 Drives: '09 G37s KH3 6MT Rep Power: 11	That's cam ghosting? Sent from my iPhone using Tapatalk

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
The 3.0 TT lives in the Q60... Doubters be relieved!	UNKNOWN_370	Other Vehicles	16	02-09-2015 11:23 AM
The Valkyrie 370Z lives on! Testing this weekend at Sonoma Raceway	a.m. Brian	Track / Autocross / Drifting / Dragstrip	20	11-10-2014 02:06 PM
Legacy lives on... 300ZX to 370Z	madmike23	New 370Z Owner	16	01-26-2014 12:46 AM
Who lives in Florida???	The Z monster	South East Region	187	09-05-2012 07:18 AM
US teen lives 118 days without heart	AK370Z	The Lounge (Off Topic)	1	11-20-2008 07:30 PM