370Z Technical Service Bulletins — 6/8/09

SoCal 370Z · 06-09-2009, 02:04 AM

Below are the current listed TSBs as of the date of this posting. Since these are simply cursory in nature, it would be very helpful if those who have access to the detail of these TSBs might consider posting them. Thank you.

AT - AUTOMATIC TRAN./TRANSAXLE:

SB Nissan; Update to AT/CVT Terminology in Service Manuals: NTB09039

SERVICE INFORMATION The terminology for Automatic Transmission ("AT") and Continuously Variable Transmission ("CVT") in the Nissan Service Manuals is being updated to reflect the terminology in SAE J1930 and J2012. When using 1994-2009 Service Manuals, please refer to the updated AT/CVT terminology in this bulletin. NOTE - Later versions of 2008 and 2009 Electronic Service Manuals will have updated AT/CVT terminology applied. See this bulletin for further detail.

EC - ENGINE CONTROL SYSTEM:

NTB09020: SB EVAP Leak DTC Diagnosis

SERVICE INFORMATION If one or more DTCs listed below related to EVAP system leaks is found stored in Self Diagnosis, use the REPAIR FLOW CHART on page 2. Use the EVAP system diagram for reference on page 3. DTCs: P0440, P0442, P0455, P0456, P1440, and P1456. See this bulletin for further detail.

SB Nissan; CONSULT-III ECM Reprogramming Procedure: NTB09029

SERVICE INFORMATION A complete step-by-step General Procedure for C-III ECM Reprogramming is now available by hyperlink in this bulletin. This General Procedure is also available via hyperlink from specific C-III symptom-based Technical Service Bulletins in ASIST. See this bulletin for further detail.

EL - ELECTRICAL SYSTEM:

SB Nissan; BCM Inspection and Configuration During Replacement: NTB07005

SERVICE INFORMATION - The "BCM Inspection and Configuration During Replacement" Service Procedure will no longer be available in Technical Service Bulletins. - The step-by-step procedure is now available only in the CONSULT-III Operation Manual. - For security reasons, the Manual is blocked from print functions. See this bulletin for further detail.

SB 2009 370Z; Door Window Operation: NTB09016

IF YOU CONFIRM: Upon opening either the driver's or passenger's door, the door windows cannot be raised with the door open. AND The battery state-of-charge is low. OR The battery (for whatever reason) had been temporarily disconnected. ACTIONS: DO NOT replace the power window motor or power window switch. If the battery state-of-charge is low: Service the battery as indicated by use of the Midtronics GR-8 Battery and Diagnostic Station using standard Warranty procedures. Re-initialize the windows using the service procedure on page 2. See this bulletin for further detail.

SB Nissan; Battery Storage and Maintenance - Vehicles in Dealer Inventory: NTB09022

SERVICE INFORMATION Proper storage and maintenance of vehicle batteries is the dealer's responsibility and an important part of insuring good battery operating life. Vehicles being stored at the dealer should have their batteries State Of Charge(SOC) routinely checked. See this bulletin for further detail.

SB Nissan; ECU Damage Can Result From Improper Battery Connection: NTB09030

SERVICE INFORMATION The vehicle 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. To prevent damage to vehicle electronic components follow the instructions / cautions in this bulletin. IMPORTANT: Damage to electronic components (ECM, TCM, BCM, etc) due to improper battery connection will not be covered under warranty.

EM - ENGINE MECHANICAL:

SB Nissan; New Blue Nissan Long Life Antifreeze/Coolant: NTB09040

SERVICE INFORMATION Beginning in calendar year 2009 some Nissan vehicles are filled at the factory with a NEW Genuine Nissan Long Life Antifreeze/Coolant (LLC) that is blue in color. See this bulletin for further detail.

HA - HEATER & AIR CONDITIONER:

SB 07-09 Z; Tapping Noise From Dash Area When Engine Is Running: NTB08053

IF YOU CONFIRM A tapping noise coming from the dash area when the engine is running at operating temperature, DETERMINE IF The noise is coming from inside the heater core (see Service Procedure). ACTION "Back-Flush" the heater core to remove gray silicone debris. See this bulletin for further detail.

TE - TOOL & EQUIPMENT:

SB Nissan; Essential Tool:J-41425 Tubing Repair Kit: NTB08110

If you find that a section of heater coolant or A/C refrigerant hard tubing needs to be replaced for any reason, the J-41425-NIS Tubing Repair Kit is now available. • This Kit will allow you, using the included tubing cutter, to cut out the damaged section and using the connectors and tools in the Kit splice in a replacement section from the matching service part. • This method of tubing repair, rather than tubing replacement, is more convienent in cases where installing the entire service partwould require major disassembly of the vehicle. See this bulletin for further details.

WT - WHEEL & TIRE:

SB 2009 370Z / 350Z; Accessory Locking Wheel Nuts: NTB09024

SERVICE INFORMATION The accessory Locking Wheel Nuts for 370Z are different then those for 350Z. When installing Locking Wheel Nuts, make sure to use the correct Part Number. See this bulletin for further detail.

AK370Z · 06-09-2009, 02:55 AM

Quote:

Originally Posted by SoCal 370Z

Below are the current listed TSBs as of the date of this posting. Since these are simply cursory in nature, it would be very helpful if those who have access to the detail of these TSBs might consider posting them. Thank you.

AT - AUTOMATIC TRAN./TRANSAXLE:

SB Nissan; Update to AT/CVT Terminology in Service Manuals: NTB09039

SERVICE INFORMATION The terminology for Automatic Transmission ("AT") and Continuously Variable Transmission ("CVT") in the Nissan Service Manuals is being updated to reflect the terminology in SAE J1930 and J2012. When using 1994-2009 Service Manuals, please refer to the updated AT/CVT terminology in this bulletin. NOTE - Later versions of 2008 and 2009 Electronic Service Manuals will have updated AT/CVT terminology applied. See this bulletin for further detail.

EC - ENGINE CONTROL SYSTEM:

NTB09020: SB EVAP Leak DTC Diagnosis

SERVICE INFORMATION If one or more DTCs listed below related to EVAP system leaks is found stored in Self Diagnosis, use the REPAIR FLOW CHART on page 2. Use the EVAP system diagram for reference on page 3. DTCs: P0440, P0442, P0455, P0456, P1440, and P1456. See this bulletin for further detail.

SB Nissan; CONSULT-III ECM Reprogramming Procedure: NTB09029

SERVICE INFORMATION A complete step-by-step General Procedure for C-III ECM Reprogramming is now available by hyperlink in this bulletin. This General Procedure is also available via hyperlink from specific C-III symptom-based Technical Service Bulletins in ASIST. See this bulletin for
further detail.

EL - ELECTRICAL SYSTEM:

SB Nissan; BCM Inspection and Configuration During Replacement: NTB07005

SERVICE INFORMATION - The "BCM Inspection and Configuration During Replacement" Service Procedure will no longer be available in Technical Service Bulletins. - The step-by-step procedure is now available only in the CONSULT-III Operation Manual. - For security reasons, the Manual is blocked from print functions. See this bulletin for further detail.

Downloadable bulletin: http://www.the370z.com/images/servic...NTB07-005a.pdf

SB 2009 370Z; Door Window Operation: NTB09016

IF YOU CONFIRM: Upon opening either the driver's or passenger's door, the door windows cannot be raised with the door open. AND The battery state-of-charge is low. OR The battery (for whatever reason) had been temporarily disconnected. ACTIONS: DO NOT replace the power window motor or power window switch. If the battery state-of-charge is low: Service the battery as indicated by use of the Midtronics GR-8 Battery and Diagnostic Station using standard Warranty procedures. Re-initialize the windows using the service procedure on page 2. See this bulletin for further detail.

Downloadable Service Bulletin http://www.the370z.com/images/servic.../NTB09-016.pdf

SB Nissan; Battery Storage and Maintenance - Vehicles in Dealer Inventory: NTB09022

SERVICE INFORMATION Proper storage and maintenance of vehicle batteries is the dealer's responsibility and an important part of insuring good battery operating life. Vehicles being stored at the dealer should have their batteries State Of Charge(SOC) routinely checked. See this bulletin for further detail.

SB Nissan; ECU Damage Can Result From Improper Battery Connection: NTB09030

[COLOR=DarkRed]SERVICE INFORMATION The vehicle 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. To prevent damage to vehicle electronic components follow the instructions / cautions in this bulletin. IMPORTANT: Damage to electronic components (ECM, TCM, BCM, etc) due to improper battery connection will not be covered under warranty

Downloadable bulletin: http://www.the370z.com/images/servic.../NTB09-030.pdf

EM - ENGINE MECHANICAL:

SB Nissan; New Blue Nissan Long Life Antifreeze/Coolant: NTB09040

SERVICE INFORMATION Beginning in calendar year 2009 some Nissan vehicles are filled at the factory with a NEW Genuine Nissan Long Life Antifreeze/Coolant (LLC) that is blue in color. See this bulletin for further detail.

HA - HEATER & AIR CONDITIONER:

SB 07-09 Z; Tapping Noise From Dash Area When Engine Is Running: NTB08053

IF YOU CONFIRM A tapping noise coming from the dash area when the engine is running at operating temperature, DETERMINE IF The noise is coming from inside the heater core (see Service Procedure). ACTION "Back-Flush" the heater core to remove gray silicone debris. See this bulletin for further detail.

Downloadable bulletin: http://www.the370z.com/images/servic...NTB08-053b.pdf

TE - TOOL & EQUIPMENT:

SB Nissan; Essential Tool:J-41425 Tubing Repair Kit: NTB08110

If you find that a section of heater coolant or A/C refrigerant hard tubing needs to be replaced for any reason, the J-41425-NIS Tubing Repair Kit is now available. • This Kit will allow you, using the included tubing cutter, to cut out the damaged section and using the connectors and tools in the Kit splice in a replacement section from the matching service part. • This method of tubing repair, rather than tubing replacement, is more convienent in cases where installing the entire service partwould require major disassembly of the vehicle. See this bulletin for further details.

WT - WHEEL & TIRE:

SB 2009 370Z / 350Z; Accessory Locking Wheel Nuts: NTB09024

SERVICE INFORMATION The accessory Locking Wheel Nuts for 370Z are different then those for 350Z. When installing Locking Wheel Nuts, make sure to use the correct Part Number. See this bulletin for further detail.

Downloadable bulletin: http://www.the370z.com/images/servic.../NTB09-024.pdf

WIPER BLADE COVER REMOVAL
http://www.the370z.com/images/servic...NTB08-111a.pdf

NISSAN; SPECIAL AUTOMATIC TRANSMISSION
FLUID REQUIREMENT
http://www.the370z.com/images/servic...NTB08-049b.pdf

Added some bulletin tonight and will update the rest tomorrow. Have to get up early for a meeting. thanks for understanding.

tru_Asiatik · 06-09-2009, 09:03 PM

i think i have/had the evap problem( believe one of the codes listed is one of the ones i got)

i had the cel come on after the exhuast/hfc install and another before that but the guys from amplified motorsports reseted/erased it with a scanner

it has not come back on since then

not sure if i should have the dealer look at it

DC370z · 06-10-2009, 05:32 PM

Can the admins make a permanent posting area for technical Service Bulletins and if possible have them as pdf in case they are needed to be brought into service.

tru_Asiatik · 06-20-2009, 11:46 PM

has anyone have word on the evap leak tsb?
the one i have is P0456
it comes on once in a while right after i put gas
i just disconnect the bat everytime it comes on(does not happend often)

keioh · 06-21-2009, 01:40 AM

Quote:

Originally Posted by tru_Asiatik

has anyone have word on the evap leak tsb?
the one i have is P0456
it comes on once in a while right after i put gas
i just disconnect the bat everytime it comes on(does not happend often)

I would take the car to the dealer.
Mine had the "Check Engine Soon" Light come on while driving as well.
They found
1: small leak found in housing where vent control valve
connects to EVAP cannister.
2: EVAP cannister broken.

they noted the code was (P0456)

Replaced both 14935 JF00A (Valve Assembly-CO), and
14950 CD00A (Cannister Assembly- E)

SO far no more light>

raps101 · 06-25-2009, 09:27 AM

I was having the (windows wont go up when doors are open problem, which magically cured itself and is working fine now, except auto up on passenger door is not working at all. Anyone have a fix for this?

iceman21_23 · 06-25-2009, 10:50 AM

take it to the dealer, i still cant believe they haven't fixed the window motor problem from the 350z

WShade · 06-25-2009, 11:01 AM

Quote:

Originally Posted by raps101

I was having the (windows wont go up when doors are open problem, which magically cured itself and is working fine now, except auto up on passenger door is not working at all. Anyone have a fix for this?

From the manual:

If the power window automatic function (closing only) does not operate properly, perform the following procedure to initialize the power window system.

1. Push the ignition switch to the ON position.
2. Close the door.
3. Open the window completely by operating the power window switch.
4. Pull the power window switch and hold it to close the window, and then hold the switch more than 3 seconds after the window is closed completely.
5. Release the power window switch. Operate the window by the automatic function to confirm the initialization is complete.
6. Perform steps 2 through 5 above for other windows.

If the power window automatic function does not operate properly after performing the procedure above, have your vehicle checked by a NISSAN dealer.

LiquidZ · 06-25-2009, 12:31 PM

How do these work? Do I just bring it into the dealer and they fix it no questions asked?

06-09-2009, 02:04 AM	#1 (permalink)
SoCal 370Z A True Z Fanatic Join Date: Feb 2009 Location: US of A Posts: 2,842 Drives: Answers Rep Power: 33	370Z Technical Service Bulletins — 6/8/09 Below are the current listed TSBs as of the date of this posting. Since these are simply cursory in nature, it would be very helpful if those who have access to the detail of these TSBs might consider posting them. Thank you. AT - AUTOMATIC TRAN./TRANSAXLE: SB Nissan; Update to AT/CVT Terminology in Service Manuals: NTB09039 SERVICE INFORMATION The terminology for Automatic Transmission ("AT") and Continuously Variable Transmission ("CVT") in the Nissan Service Manuals is being updated to reflect the terminology in SAE J1930 and J2012. When using 1994-2009 Service Manuals, please refer to the updated AT/CVT terminology in this bulletin. NOTE - Later versions of 2008 and 2009 Electronic Service Manuals will have updated AT/CVT terminology applied. See this bulletin for further detail. EC - ENGINE CONTROL SYSTEM: NTB09020: SB EVAP Leak DTC Diagnosis SERVICE INFORMATION If one or more DTCs listed below related to EVAP system leaks is found stored in Self Diagnosis, use the REPAIR FLOW CHART on page 2. Use the EVAP system diagram for reference on page 3. DTCs: P0440, P0442, P0455, P0456, P1440, and P1456. See this bulletin for further detail. SB Nissan; CONSULT-III ECM Reprogramming Procedure: NTB09029 SERVICE INFORMATION A complete step-by-step General Procedure for C-III ECM Reprogramming is now available by hyperlink in this bulletin. This General Procedure is also available via hyperlink from specific C-III symptom-based Technical Service Bulletins in ASIST. See this bulletin for further detail. EL - ELECTRICAL SYSTEM: SB Nissan; BCM Inspection and Configuration During Replacement: NTB07005 SERVICE INFORMATION - The "BCM Inspection and Configuration During Replacement" Service Procedure will no longer be available in Technical Service Bulletins. - The step-by-step procedure is now available only in the CONSULT-III Operation Manual. - For security reasons, the Manual is blocked from print functions. See this bulletin for further detail. SB 2009 370Z; Door Window Operation: NTB09016 IF YOU CONFIRM: Upon opening either the driver's or passenger's door, the door windows cannot be raised with the door open. AND The battery state-of-charge is low. OR The battery (for whatever reason) had been temporarily disconnected. ACTIONS: DO NOT replace the power window motor or power window switch. If the battery state-of-charge is low: Service the battery as indicated by use of the Midtronics GR-8 Battery and Diagnostic Station using standard Warranty procedures. Re-initialize the windows using the service procedure on page 2. See this bulletin for further detail. SB Nissan; Battery Storage and Maintenance - Vehicles in Dealer Inventory: NTB09022 SERVICE INFORMATION Proper storage and maintenance of vehicle batteries is the dealer's responsibility and an important part of insuring good battery operating life. Vehicles being stored at the dealer should have their batteries State Of Charge(SOC) routinely checked. See this bulletin for further detail. SB Nissan; ECU Damage Can Result From Improper Battery Connection: NTB09030 SERVICE INFORMATION The vehicle 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. To prevent damage to vehicle electronic components follow the instructions / cautions in this bulletin. IMPORTANT: Damage to electronic components (ECM, TCM, BCM, etc) due to improper battery connection will not be covered under warranty. EM - ENGINE MECHANICAL: SB Nissan; New Blue Nissan Long Life Antifreeze/Coolant: NTB09040 SERVICE INFORMATION Beginning in calendar year 2009 some Nissan vehicles are filled at the factory with a NEW Genuine Nissan Long Life Antifreeze/Coolant (LLC) that is blue in color. See this bulletin for further detail. HA - HEATER & AIR CONDITIONER: SB 07-09 Z; Tapping Noise From Dash Area When Engine Is Running: NTB08053 IF YOU CONFIRM A tapping noise coming from the dash area when the engine is running at operating temperature, DETERMINE IF The noise is coming from inside the heater core (see Service Procedure). ACTION "Back-Flush" the heater core to remove gray silicone debris. See this bulletin for further detail. TE - TOOL & EQUIPMENT: SB Nissan; Essential Tool:J-41425 Tubing Repair Kit: NTB08110 If you find that a section of heater coolant or A/C refrigerant hard tubing needs to be replaced for any reason, the J-41425-NIS Tubing Repair Kit is now available. • This Kit will allow you, using the included tubing cutter, to cut out the damaged section and using the connectors and tools in the Kit splice in a replacement section from the matching service part. • This method of tubing repair, rather than tubing replacement, is more convienent in cases where installing the entire service partwould require major disassembly of the vehicle. See this bulletin for further details. WT - WHEEL & TIRE: SB 2009 370Z / 350Z; Accessory Locking Wheel Nuts: NTB09024 SERVICE INFORMATION The accessory Locking Wheel Nuts for 370Z are different then those for 350Z. When installing Locking Wheel Nuts, make sure to use the correct Part Number. See this bulletin for further detail. __________________ ( Click to show/hide ) Why I NEVER say NO to the Panda Lou Fusz!!!

06-09-2009, 09:03 PM	#3 (permalink)
tru_Asiatik Track Member Join Date: Feb 2009 Location: so cal Posts: 793 Drives: 2009 370Z 6MT Rep Power: 270	i think i have/had the evap problem( believe one of the codes listed is one of the ones i got) i had the cel come on after the exhuast/hfc install and another before that but the guys from amplified motorsports reseted/erased it with a scanner it has not come back on since then not sure if i should have the dealer look at it __________________ Stillen G3 CAIStillen CBEBerk's HFCEibach ProkitHotchkis Swaysichiba 15/20mm spacers? Oil coolerStillen PulleyStillen Headers

06-20-2009, 11:46 PM	#5 (permalink)
tru_Asiatik Track Member Join Date: Feb 2009 Location: so cal Posts: 793 Drives: 2009 370Z 6MT Rep Power: 270	has anyone have word on the evap leak tsb? the one i have is P0456 it comes on once in a while right after i put gas i just disconnect the bat everytime it comes on(does not happend often) __________________ Stillen G3 CAIStillen CBEBerk's HFCEibach ProkitHotchkis Swaysichiba 15/20mm spacers? Oil coolerStillen PulleyStillen Headers

06-25-2009, 12:31 PM	#10 (permalink)
LiquidZ A True Z Fanatic Join Date: Nov 2008 Location: Columbus, OH Posts: 1,940 Drives: Mag. Black 2009 370Z Rep Power: 705	How do these work? Do I just bring it into the dealer and they fix it no questions asked? __________________

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
2009 370z Service Manual Complete ready to Download!	kdo2milger	Nissan 370Z Owners Manual / Service Manuals	139	04-09-2021 04:54 PM
Nissan's Stance on Posting Service Bulletins?	SoCal 370Z	Nissan 370Z General Discussions	6	04-02-2010 09:28 PM
2009 Nissan 370Z Service & Maintenance Guide (PDF, 7.36MB)	AK370Z	Nissan 370Z Owners Manual / Service Manuals	9	03-30-2009 10:10 AM
370z Factory Service Manual	modme	Nissan 370Z General Discussions	29	03-17-2009 08:48 AM

06-10-2009, 05:32 PM	#4 (permalink)
DC370z Base Member Join Date: Mar 2009 Location: LA Posts: 8 Drives: 09PW6MT Rep Power: 16	Can the admins make a permanent posting area for technical Service Bulletins and if possible have them as pdf in case they are needed to be brought into service.

06-25-2009, 09:27 AM	#7 (permalink)
raps101 Base Member Join Date: Jun 2009 Location: New York Posts: 60 Drives: 09 Nissan 370z T/M6 Rep Power: 16	I was having the (windows wont go up when doors are open problem, which magically cured itself and is working fine now, except auto up on passenger door is not working at all. Anyone have a fix for this?

06-25-2009, 10:50 AM	#8 (permalink)
iceman21_23 Track Member Join Date: Jan 2009 Location: league city, tx Posts: 757 Drives: 09' Solid Red 370z Rep Power: 17	take it to the dealer, i still cant believe they haven't fixed the window motor problem from the 350z