clutch pedal issues?

xgrudgex · 01-15-2011, 08:55 PM

Just today I had some issues when shifting at highway speeds, just wanted to see if anyone else had any of the same issues?
Well basically I was driving in 5th gear thru slow traffic... about 15 minutes(I'm in cali lol)
And when speed picked up I went to shift but I had about 6 inches of dead pedal and the last inch I had pressure.... wtf!?
So I popped it in neutral and tried hitting the clutch repeatedly to maybe build the pressure up but no go, pulled over, after about a minute of ddriving thru the streets it came back!
So fluids are good, belts tight, the only thing I'm low on is window piss so I'm confues:/ any ideas or anyone else have a similar issue?

kenchan · 01-16-2011, 11:59 AM

Why were you in 5th? Should be 3rd and lowerfor slow traffic... creeping traffic I only use 1st.

Zat_Zuma · 01-16-2011, 12:08 PM

It sounds like your clutch fluid need replacing.
The soft pedal condition can happen if you have air in the system or if the fluid is past it's boiling point and that can cause the symptoms you've described. Sometimes if the clutch fluid has absorbed water or seen too much heat once too often, the boiling point of the fluid drops dramatically and will start to vaporize in the line and lose the hydraulic properties of the fluids. The best recourse is to flush and replace the clutch fluid with a quality brake fluid with a higher boiling point. Clutch fluid is the same stuff as brake fluid, if you were wondering.

Hope that helps

jaedub · 01-16-2011, 03:16 PM

you sure your clutch fluid didnt leak?

xgrudgex · 01-17-2011, 03:55 PM

Quote:

Originally Posted by kenchan

Why were you in 5th? Should be 3rd and lowerfor slow traffic... creeping traffic I only use 1st.

Always someone on here trying to make someone look stupid... I was actualy coasting in "slower" than what highway speed... not 35 mph it was speed up and slow down from 45-60 which I feel 5th gear was appropriate. But thanks for trying to explain how I should drive my car

As for the issue it was the brake booster.... so they say which makes sense since all fluids were where they should be, I dont think it was a leak just more of a malfunction, either way sucks for me since I will be paying out of pocket for it since I am past the 35k mile coverage.... lameeeee

mcwoowoo · 01-21-2011, 01:06 AM

I just got the same issue, clutch paddle lost pressure. I started to notice the clutch felt very soft for the first half and the engagement point felt like it had shifted to the bottom. Yesterday, the while driving on freeway and coming to traffic stop the clutch paddle got stuck to the floor when I down-shifted. The problem seemed very apparent on freeway, and less for local driving. I when to the dealership and 2 hours later they said they have to replace the Master and Slave clutch cylinders per Nissan Tech Support.

Pharmacist · 01-22-2011, 12:11 PM

Quote:

Originally Posted by xgrudgex

Always someone on here trying to make someone look stupid... I was actualy coasting in "slower" than what highway speed... not 35 mph it was speed up and slow down from 45-60 which I feel 5th gear was appropriate. But thanks for trying to explain how I should drive my car

As for the issue it was the brake booster.... so they say which makes sense since all fluids were where they should be, I dont think it was a leak just more of a malfunction, either way sucks for me since I will be paying out of pocket for it since I am past the 35k mile coverage.... lameeeee

hold on, why would the brake booster affect the clutch? they are not connected in any way. if the brake booster failed, it will be your brake pedal that will feel different, and it will be harder, not softer.

Israeli_Z · 01-25-2011, 06:49 AM

Quote:

Originally Posted by xgrudgex

Just today I had some issues when shifting at highway speeds, just wanted to see if anyone else had any of the same issues?
Well basically I was driving in 5th gear thru slow traffic... about 15 minutes(I'm in cali lol)
And when speed picked up I went to shift but I had about 6 inches of dead pedal and the last inch I had pressure.... wtf!?
So I popped it in neutral and tried hitting the clutch repeatedly to maybe build the pressure up but no go, pulled over, after about a minute of ddriving thru the streets it came back!
So fluids are good, belts tight, the only thing I'm low on is window piss so I'm confues:/ any ideas or anyone else have a similar issue?

I've had the same thing since day one. I always thought it was normal...my clutch only engages 2 inches from the top and the rest doesn't do anything. I don't even depress my clutch all the way because it seems like there is no point. Now I'm paranoid!!!

RockStarKick · 01-25-2011, 10:49 AM

Quote:

Originally Posted by Israeli_Z

I've had the same thing since day one. I always thought it was normal...my clutch only engages 2 inches from the top and the rest doesn't do anything. I don't even depress my clutch all the way because it seems like there is no point. Now I'm paranoid!!!

Check this thread out clutch high engagement point

Israeli_Z · 01-26-2011, 06:48 AM

Quote:

Originally Posted by RockStarKick

Check this thread out clutch high engagement point

Thanks. I'll bookmark that page but I actually don't mind the high engagement...just wanted to make sure it wasn't affecting or damaging anything.

Endgame · 01-27-2011, 02:20 PM

If I were to go through the process and lower my engagement point, if I had experined the above issue xgrudgex experiences, do I risk damage to the clutch? would it not fully disengage?

RockStarKick · 01-27-2011, 02:38 PM

I would think not.. As long as you make sure that the clutch is fully engaging/disengaging.

I personally like the engagement point of my clutch, it engages about 40% from the floor.

CrownR426 · 01-27-2011, 02:49 PM

The first winter I had my car I was on my way back from the mall and my clutch pedal was stuck to the floor. I was scared because I was in traffic. Stalled my car and got so mad... Turned the car back and and the problem was gone. o____O;; I know I've read a few posts of people saying the same. I should've gone to my dealer the next day for service.

Endgame · 01-27-2011, 03:07 PM

Quote:

Originally Posted by RockStarKick

I would think not.. As long as you make sure that the clutch is fully engaging/disengaging.

I personally like the engagement point of my clutch, it engages about 40% from the floor.

Thanks. My engagement point is a little on the high side; I just want to lower it some, maybe 1 turn....

cheshirecat · 01-28-2011, 11:08 AM

IMO, this sounds like hot/boiling clutch fluid, not an engagement point issue.

Change out the fluid to a DOT4 blend like Motul RBF600. You may also want to consider upgrading to a stainless steel clutch line. Neither of these are expensive and the install is very straightforward. The biggest pain in the *** is just getting the air out of the system once it's installed.

01-15-2011, 08:55 PM	#1 (permalink)
xgrudgex Base Member Join Date: Jul 2010 Location: California Age: 38 Posts: 111 Drives: My neighbors crazy Rep Power: 15	clutch pedal issues? Just today I had some issues when shifting at highway speeds, just wanted to see if anyone else had any of the same issues? Well basically I was driving in 5th gear thru slow traffic... about 15 minutes(I'm in cali lol) And when speed picked up I went to shift but I had about 6 inches of dead pedal and the last inch I had pressure.... wtf!? So I popped it in neutral and tried hitting the clutch repeatedly to maybe build the pressure up but no go, pulled over, after about a minute of ddriving thru the streets it came back! So fluids are good, belts tight, the only thing I'm low on is window piss so I'm confues:/ any ideas or anyone else have a similar issue?

01-16-2011, 12:08 PM	#3 (permalink)
Zat_Zuma A True Z Fanatic Join Date: Nov 2008 Location: Edmonton, Alberta ...eh Posts: 1,171 Drives: 2017 Touring auto Rep Power: 19	It sounds like your clutch fluid need replacing. The soft pedal condition can happen if you have air in the system or if the fluid is past it's boiling point and that can cause the symptoms you've described. Sometimes if the clutch fluid has absorbed water or seen too much heat once too often, the boiling point of the fluid drops dramatically and will start to vaporize in the line and lose the hydraulic properties of the fluids. The best recourse is to flush and replace the clutch fluid with a quality brake fluid with a higher boiling point. Clutch fluid is the same stuff as brake fluid, if you were wondering. Hope that helps __________________ [B]2009 & 2017 370Z Touring Sport Autos SOLD

01-27-2011, 02:38 PM	#12 (permalink)
RockStarKick Enthusiast Member Join Date: Dec 2010 Location: Houston Posts: 298 Drives: it like a rental Rep Power: 15	I would think not.. As long as you make sure that the clutch is fully engaging/disengaging. I personally like the engagement point of my clutch, it engages about 40% from the floor. __________________ 2013 Mustang GT, 6M, Track Pack & Leather Recaros 2011 Pearl White 6M /Sport Pkg - SOLD

01-27-2011, 02:49 PM	#13 (permalink)
CrownR426 A True Z Fanatic Join Date: Nov 2008 Location: South Korea Posts: 4,676 Drives: Manual Rep Power: 848	The first winter I had my car I was on my way back from the mall and my clutch pedal was stuck to the floor. I was scared because I was in traffic. Stalled my car and got so mad... Turned the car back and and the problem was gone. o____O;; I know I've read a few posts of people saying the same. I should've gone to my dealer the next day for service. __________________ Love + Hardwork + Passion RIP SVTRacer

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
light clutch pedal?	boosted180	Engine & Drivetrain	21	06-07-2014 02:53 PM
Gas pedal piviot issues.	Guard Dad	Nissan 370Z General Discussions	46	11-06-2013 08:31 PM
6 speed manual without the clutch pedal	Nissan370z	Nissan 370Z General Discussions	24	07-24-2011 09:09 AM
Change in clutch pedal pressure.	Soygen	Engine & Drivetrain	8	04-27-2011 12:53 AM
Knock from the clutch pedal	Oscar135	Engine & Drivetrain	34	07-27-2010 01:10 PM

01-16-2011, 11:59 AM	#2 (permalink)
kenchan A True Z Fanatic Join Date: Aug 2009 Location: N/A Posts: 76,801 Drives: N/A Rep Power: 141521	Why were you in 5th? Should be 3rd and lowerfor slow traffic... creeping traffic I only use 1st.

01-16-2011, 03:16 PM	#4 (permalink)
jaedub Track Member Join Date: Aug 2010 Location: Los Angeles Posts: 906 Drives: 2010 Black 370Z MT Rep Power: 305	you sure your clutch fluid didnt leak?

01-21-2011, 01:06 AM	#6 (permalink)
mcwoowoo Base Member Join Date: Sep 2009 Location: SAN MATEO, CA Posts: 22 Drives: EVO9,C350,FX35,370Z Rep Power: 16	I just got the same issue, clutch paddle lost pressure. I started to notice the clutch felt very soft for the first half and the engagement point felt like it had shifted to the bottom. Yesterday, the while driving on freeway and coming to traffic stop the clutch paddle got stuck to the floor when I down-shifted. The problem seemed very apparent on freeway, and less for local driving. I when to the dealership and 2 hours later they said they have to replace the Master and Slave clutch cylinders per Nissan Tech Support.

01-27-2011, 02:20 PM	#11 (permalink)
Endgame A True Z Fanatic Join Date: Nov 2008 Location: Phoenix Posts: 1,613 Drives: Nothing Now! Rep Power: 224	If I were to go through the process and lower my engagement point, if I had experined the above issue xgrudgex experiences, do I risk damage to the clutch? would it not fully disengage?

01-28-2011, 11:08 AM	#15 (permalink)
cheshirecat A True Z Fanatic Join Date: Jan 2009 Location: Florida Posts: 1,428 Drives: N54 135i Rep Power: 292	IMO, this sounds like hot/boiling clutch fluid, not an engagement point issue. Change out the fluid to a DOT4 blend like Motul RBF600. You may also want to consider upgrading to a stainless steel clutch line. Neither of these are expensive and the install is very straightforward. The biggest pain in the *** is just getting the air out of the system once it's installed.