MT Oil consumption failure

Mt Tam I am · 11-01-2010, 12:36 PM

Just got off phone with Nissan engineer regarding questions I had regarding oil consumption and catalytic convertors. I had a short block replacement due to oil consumption.

His responses:
Oil consumption failure is greatest in manuel transmissions due to down shifts above 5,000 rpm creating negative vacuum*. Oil viscosity break down does not necessarily begin between 240*F - 260*F. So no need to worry, you are under warranty.

Catalytic convertors are not necessarily effected by six quarts of oil burnt over them. Maybe effected. Diagnosis: you are under warranty. No need for replacement. I pointed out my first smog check is at four years, one year after warranty. Silence followed by "you are under warranty."

Q. How does the car run now?
A. Just as well and well as when it burned one quart of oil every 500 miles. Only less smoke out the tail pipes.

* My car failed before 500 miles in all likelihood during break in, as I was down 3/4th quarts. Six quarts by 2,900.

spearfish25 · 11-01-2010, 01:37 PM

Quote:

Originally Posted by Mt Tam I am

Oil consumption failure is greatest in manuel transmissions due to down shifts above 5,000 rpm creating negative vacuum.

I'm not sure what he means by that. He's implying that people with oil consumption issues downshift into high RPMs frequently? Or does doing a few high RPM downshifts then induce a persistent oil consumption thereafter?

VCuomo · 11-01-2010, 02:19 PM

Quote:

Originally Posted by Mt Tam I am

...Catalytic convertors are not necessarily effected by six quarts of oil burnt over them. Maybe effected. Diagnosis: you are under warranty. No need for replacement. I pointed out my first smog check is at four years, one year after warranty. Silence followed by "you are under warranty."...

Your warranty on the catalytic converters is not necessarily over at 3 years - by Federal law, a manufacturer's warranty is required for all new vehicles covering smog pollution reduction equipment for a minimum of 8 years or 80,000 miles, whichever occurs first.

PapoZalsa · 11-01-2010, 02:37 PM

Quote:

Originally Posted by spearfish25

I'm not sure what he means by that. He's implying that people with oil consumption issues downshift into high RPMs frequently? Or does doing a few high RPM downshifts then induce a persistent oil consumption thereafter?

Well what is the SRM for then?

kenchan · 11-01-2010, 03:40 PM

i down shift my honda at near redline frequently and yet oil consumption is minimal.

on the z i downshift quite high but around 4-5k. my oil consumption is not measureable... im at 4k miles.

i too dont know wat the nissan engineer said.

did he start making up acronyms by any chance?

spearfish25 · 11-01-2010, 03:54 PM

Quote:

Originally Posted by Mt Tam I am

Oil consumption failure is greatest in manuel transmissions...

Who is Manuel? Were our transmissions made in Mexico?

kenchan · 11-01-2010, 04:01 PM

Quote:

Originally Posted by spearfish25

Who is Manuel? Were our transmissions made in Mexico?

no, only the designer was mexican.

c41006 · 11-01-2010, 04:01 PM

Quote:

Originally Posted by spearfish25

Who is Manuel? Were our transmissions made in Mexico?

WShade · 11-01-2010, 04:01 PM

Quote:

Originally Posted by spearfish25

Who is Manuel? Were our transmissions made in Mexico?

Stop that..... This is a good info thread.

6MT · 11-01-2010, 04:08 PM

Quote:

Originally Posted by Mt Tam I am

His responses:
Oil consumption failure is greatest in manuel transmissions due to down shifts above 5,000 rpm creating negative vacuum*. Oil viscosity break down does not necessarily begin between 240*F - 260*F. So no need to worry, you are under warranty.

Catalytic convertors are not necessarily effected by six quarts of oil burnt over them. Maybe effected. Diagnosis: you are under warranty. No need for replacement. I pointed out my first smog check is at four years, one year after warranty. Silence followed by "you are under warranty."

cab83_750 · 11-01-2010, 04:12 PM

Ok guys. Let's not be ethnic; else you guys get banned.

OP,

Does your rebuilt motor still burn oil? How much?

billydsz · 11-01-2010, 04:29 PM

I don't even know why I bothered clicking on this post.

Ktown · 11-01-2010, 04:30 PM

My engine failed beore 6000 kM. They did the short block replacement. They said there was some problems in the early models, but the new block had a fix for it. Well I checked the oil and after 3000 Km it needed more. So I don't think there was a "fix". Interesting to see the "vacume" theory. In my case I doubt that happens very often.

Mt Tam I am · 11-01-2010, 04:33 PM

Quote:

Originally Posted by spearfish25

I'm not sure what he means by that. He's implying that people with oil consumption issues downshift into high RPMs frequently? Or does doing a few high RPM downshifts then induce a persistent oil consumption thereafter?

He's implying that people with oil consumption issues downshift into high RPMs frequently?

He said Nissans' observation is that people with MT down shift more than those who drive AT's. Higher revolutions and making the engine work harder wears out faster. (Yeah no kidding). So I asked him about the SRM and should I not use it during break in. Answer: The SRM helps with engine break in and smooth shifting.

I am not 100% sure he was actually a real engineer.

WShade · 11-01-2010, 04:35 PM

Quote:

Originally Posted by Ktown

My engine failed beore 6000 kM. They did the short block replacement. They said there was some problems in the early models, but the new block had a fix for it. Well I checked the oil and after 3000 Km it needed more. So I don't think there was a "fix". Interesting to see the "vacume" theory. In my case I doubt that happens very often.

How much more is the question. OP was using 6qt every 2900 miles. That is the very definition of excessive. 1- 1.5qt every 3000 miles would not bother me in the least.

11-01-2010, 12:36 PM	#1 (permalink)
Mt Tam I am A True Z Fanatic Join Date: Jun 2010 Location: California Posts: 10,709 Drives: 370Z T/S/N 6MT & XKE Rep Power: 3843	MT Oil consumption failure Just got off phone with Nissan engineer regarding questions I had regarding oil consumption and catalytic convertors. I had a short block replacement due to oil consumption. His responses: Oil consumption failure is greatest in manuel transmissions due to down shifts above 5,000 rpm creating negative vacuum. Oil viscosity break down does not necessarily* begin between 240F - 260F. So no need to worry, you are under warranty. Catalytic convertors are not necessarily effected by six quarts of oil burnt over them. Maybe effected. Diagnosis: you are under warranty. No need for replacement. I pointed out my first smog check is at four years, one year after warranty. Silence followed by "you are under warranty." Q. How does the car run now? A. Just as well and well as when it burned one quart of oil every 500 miles. Only less smoke out the tail pipes. * My car failed before 500 miles in all likelihood during break in, as I was down 3/4th quarts. Six quarts by 2,900. __________________ "Does the carpet match the drapes? NO!!! I don't date bald women." Nissan Motorsports 34R Oil Cooler. Stillen CBE. Hotchkis Sport Sway Bars. KW Variant 3 Coilover System. Stillen Gen3 CAI. Michelin Pilot Super Sport. Stillen Brake Ducts. Carbotech™ XP10/XP8 Pads. Z1 Front Rotors. Z1 Stainless Brake Lines. Two degrees of camber

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
HFC Failure, ever have it happen?	spearfish25	Intake/Exhaust	19	11-05-2013 08:18 PM
Nismo Brake Failure	RedNismo	Brakes & Suspension	18	05-08-2010 12:20 AM
Sudden Brake failure at VIR	Joehand1	Nissan 370Z General Discussions	1	01-10-2010 04:39 PM
Heated Seats Failure	jmtt90	Nissan 370Z General Discussions	14	12-12-2009 05:45 PM
Transmission failure	1slow370	Nissan 370Z General Discussions	32	10-22-2009 03:39 PM

11-01-2010, 03:40 PM	#5 (permalink)
kenchan A True Z Fanatic Join Date: Aug 2009 Location: N/A Posts: 76,801 Drives: N/A Rep Power: 141521	i down shift my honda at near redline frequently and yet oil consumption is minimal. on the z i downshift quite high but around 4-5k. my oil consumption is not measureable... im at 4k miles. i too dont know wat the nissan engineer said. did he start making up acronyms by any chance?

11-01-2010, 04:12 PM	#11 (permalink)
cab83_750 Track Member Join Date: Apr 2009 Location: CA Posts: 887 Drives: 09 NISSAN 370Z Rep Power: 417	Ok guys. Let's not be ethnic; else you guys get banned. OP, Does your rebuilt motor still burn oil? How much?

11-01-2010, 04:29 PM	#12 (permalink)
billydsz Enthusiast Member Join Date: Aug 2009 Location: New Bern Posts: 252 Drives: 9 370z SptCp SRd 7AT Rep Power: 16	I don't even know why I bothered clicking on this post.

11-01-2010, 04:30 PM	#13 (permalink)
Ktown Base Member Join Date: Jul 2010 Location: Kelowna Posts: 6 Drives: 370Z Rep Power: 15	My engine failed beore 6000 kM. They did the short block replacement. They said there was some problems in the early models, but the new block had a fix for it. Well I checked the oil and after 3000 Km it needed more. So I don't think there was a "fix". Interesting to see the "vacume" theory. In my case I doubt that happens very often.