TSB for oil consumption on the VQ37VHR.

shumby

Hello Everyone,

Here is a fairly recent TSB for oil consumption on the VQ37VHR.
Here is a link to the PDF: http://www.infinitig37.com/TSB/1SY30.pdf


Classif ication: Reference: Date:
EM10-006 ITB10-048 July 30, 2010
2008 – 2010 G37; ENGINE OIL LEVEL IS LOW
APPLIED 2009 - 2010 G37 Sedan (V36)
VEHICLES: 2008 - 2010 G37 Coupe (CV36)
2009 - 2010 G37 Convertible (HV36)
APPLIED
VQ37VHR ONLY
ENGINE:
2008-2009 G37 Coupe\Sedan & 2009 Convertible: All
APPLIED VIN /
DATE: 2010 G37 Coupe vehicles built from:
JN1CV6EK(*)AM100001 to JN1CV6EK(*)AM102428 up to 05-Apr-2010
JN1CV6EL(*)AM150001 to JN1CV6EL(*)AM152039 up to 05-Apr-2010
2010 G37 Sedan vehicles built from:
JN1CV6AP(*)AM200001 to JN1CV6AP(*)AM202365 up to 02-Apr-2010
JN1CV6AR(*)AM250001 to JN1CV6AR(*)AM252477 up to 02-Apr-2010
JN1CV6AP(*)AM400001 to JN1CV6AP(*)AM406683 up to 05-Apr-2010
JN1CV6AR(*)AM450001 to JN1CV6AR(*)AM458374 up to 05-Apr-2010
2010 G37 Convertible vehicles built from:
Automatic Transmission equipped:
JN1CV6FE(*)AM351001 to JN1CV6FE(*)AM351532 up to 05-Apr-2010
JN1CV6FE(*)AM350001 to JN1CV6FE(*)AM350542 up to 18-Dec-2009
Manual Transmission equipped:
JN1CV6FE(*)AM351001 to JN1CV6FE(*)AM351899 up to 06-Apr-2010
JN1CV6FE(*)AM350001 to JN1CV6FE(*)AM350749 up to 12-Jan-2010
IF YOU CONFIRM
Engine oil level is low OR there is unusual engine noise.
ACTION
Use the “Repair Flow Chart” in the Service Procedure on page 2 to determine the complete repair procedures
for a specific vehicle.
CAUTION: If the short engine is replaced as part of this bulletin, please advise the customer to follow
the Owner’s Manual Engine “Break-in Schedule” for the first 1,200 miles including:
• DO NOT RUN THE ENGINE OVER 4,000 RPM.
• DO NOT ACCELERATE AT FULL THROTTLE.
NOTE: Check OBD-II “Engine” Self Diagnosis for any stored DTC codes and use the appropriate Electronic
Service Manual (ESM) to repair any DTC code found stored.
Infiniti Bulletins are intended for use by qualified technicians, not 'do-it-yourselfers'. Qualified technicians are properly trained
individuals who have the equipment, tools, safety instruction, and know-how to do a job properly and safely. NOTE: If you believe
that a described condition may apply to a particular vehicle, DO NOT assume that it does. See your Infiniti dealer to determine if this
applies to your vehicle.

__________________
Originally Posted by SAM@GTM
Engine detonation is not normal and it should never never happen, and whoever told that need to do something else for living .
Sam

shumby

^^ so there it is for the G any word on this for the Z?

__________________
Originally Posted by SAM@GTM
Engine detonation is not normal and it should never never happen, and whoever told that need to do something else for living .
Sam

370zproject

suscribed

__________________

Brake Upgrade Package ate blue, hawk hp ceramic pads, and slotted rotors

WarmAndSCSI

LMAO perfect way to ensure repeat repairs Nissan, GG.

__________________

ZForce

Oh lordy...not again....06 Z33 RevUp MT replaced...I am having too much fun with this car (Z34) for another OC issue.

daleks

Interesting. The chart shows that if you burn >2mm of oil per ~500 miles (beyond 9mm) then there is an issue. Is the dipstick the same on the 370Z and the G37? Probably so.

Cmike2780

Subscribed

__________________

[09][MB][6-Spd MT][Touring][Stillen Gen III][K&N][Borla CBE][Evo-R]

spearfish25

Subscribed. I can only imagine the problems I'll endure if any Nissan dealer in my area tries to replace the engine. Even if I had consumption issues, I might rather refill the oil frequently rather than run the gauntlet of engine replacement by numbnuts.

__________________
2013 Cadillac V-Wagon, RIP Z

gpa7pk

Subscribed

menzzer37

subscribed as well

Valentino

Subscribed.

__________________
Lou Fusz Nissan | KW V3 | SPL rear camber and toe bolt | OS Giken LSD | Nismo Diff cover | Engine Oil cooler | F.I. TDX Cat Back 18" Resonators | F.I. Resonated Test Pipes | Injen cold air intake | COBB AccessPORT | JWT Clutch Flywheel |

ZForce

There are a lot of dealer horror stories on the Z33 Revup engine replacement on my350Z oil consumption thread. Ya just don't know who is out there turning the wrench. The Bros 06 Z33 engine swap was perfect with our local dealrship in Roseville / Sacramento area. It was their third engine swap and it was flawless.

I have been tracking both Z34's oil readings every week and the bros is in the safe zone by a long shot. Mine was close to No Good at 1925 miles at 10mm oil consumption. Thereafter it stayed in the safe zone through out the 5k oil change interval. By the time it hit 5k miles there was 16mm of oil consumption which equates to about 3/4 of a quart. No cigar this time around. Then again the 06 Z33 did not really start consuming allot of oil until the odo hit between 22k miles and higher. I am currently at 21k miles on the odo. So if it holds true to 06 Z33 engines, this engine could start consuming more on the next oil change interval. Fingers crossed it does not.

PapoZalsa

Subscribed.

And I traded my 2006 MT for a 370Z...

__________________
2009 370Z MB Base w/Sport Package 6MT
Modshack's Custom Air Intakes /3M Clear Bra/ Illuminated Kick Plates / F. I CBE w/12" resonators / EVO-R Front Lip / Rear Hatch Wing / Tein S-Tech Springs /Ilegal Tint in the Rep. of VA/4x20mm Z1 Spacers/ Vinyl Roof/Liquid Carbon Designs

I Run L.A.

Its funny i read this today.. about 2 weeks ago i changed my oil at 5K interval, car now has 20K. To my surprised i only drained about 3 quarts and 1/2 which means the car comsumed the rest which is a lot. I need to take it to the dealer.

__________________
09 370Z Mag Blk, 6MT,Tour, Sprt Pkg, Nav

ZForce

Hopefully you received a fair trade in value for 06. Sold the bros 06 for $15k with 15k on the new engine, total of 42k on the odo.

Ouch...yes indeed that is a lot of oil consumption. I would def get it into the dealer and at least have it reported on a service order that "customer states engine is consuming excessive amount of oil between oil changes". It's important to get documented on your file even if they do not have a TSB yet for the 370Z. It MAY help if you ever have to Lemon Law the car, although I believe Cali Law is 18k miles to have the issue reported to manufacture. Either way they would pro rate the mileage on the car if it ever comes down to a buy back.

I would also ask the dealer to start an oil consumption test on the car and if they look at you funny....then run fast to another dealer. You should be checking your oil weekly and when it’s cold (sat over night). The dipstick High / Low hash marks are 24mm between the high mark (hole) and the low mark (hole). And the mm between the high and low marks is 24mm which equals to 1 quart.

If this issue starts to raise its ugly head on the 370Z then a new thread should be opened, because it will get long. Just look at my350z thread, it's at 219 pages. RevUp Oil Consumption TSB and discussion - MY350Z.COM Forums